MILLER ENPAK A60 9999: EQUIPMENT:ELECTRICAL

NHTSA Campaign ID Number: 22E025000

Manufacturers Involved: Miller Electric Mfg. Co.

Component: EQUIPMENT:ELECTRICAL

Potential Number Of Units Affected: 296

Report Initiator: MFR MFR Report

Miller Electric MFG. CO. "Miller" is recalling certain EnPak A60 Diesel Engine-Driven All-In-One Air Compressor/Generator/Battery Charger/Crank Assist/Hydraulic Pump/Welder "Model A60GB - Stock Numbers 907813, 907813001, Model A60GBH - Stock Numbers 907814, 907814001 and Model A60GBHW - Stock Numbers 907815, 907815001". All units are within the following serial number range NB290697R " NC080172R and were manufactured between July 16, 2021, and February 16, 2022. A bracket inside the EnPak All-In-One unit may have been installed with inadequate clearance, allowing the drive belt to contact other components, and potentially causing damage to the ground wire, battery cables, and fuel hoses. In addition, a lack of clearance between the output inductor and EnPak All-In-One frame may cause an electrical arc.

A damaged power cable or diesel fuel hose can cause an electrical short-circuit or fuel leak. Output inductor contact with the frame can cause an electrical arc. Any of these scenarios can increase the risk of a fire.

Dealers will inspect and replace the ground wire, battery cables, and fuel hoses, as necessary, and install a larger bracket. A new bracket will also be installed between the output inductor and frame. Repairs will be performed free of charge. Vehicle upfitters were notified February 28, 2022. Owner letters were mailed May 27, 2022. Owners may contact Miller customer service at 1-920-735-4505.

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 'TTY 1-800-424-9153', or go to www.nhtsa.gov. Please be reminded of the following requirements:You are required to submit a draft owner notification letter to this office no less than five days prior to mailing it to the customers.Also, copies of all notices, bulletins, dealer notifications, and other communications that relate to this recall, including a copy of the final owner notification letter and any subsequent owner follow-up notification letter's', are required to be submitted to this office no later than 5 days after they are originally sent 'if they are sent to more than one manufacturer, distributor, dealer, or purchaser/owner'.Please be reminded that under 49 U.S.C. ' 30112'a''3', it is illegal for a manufacturer, to sell, offer for sale, import, or introduce or deliver into interstate commerce, a motor vehicle or item of motor vehicle equipment that contains a safety defect once the manufacturer has notified NHTSA about that safety defect.This prohibition does not apply once the motor vehicle or motor vehicle equipment has been remedied according to the manufacturer's instructions.As stated in Part 573.7, submission of the first of eight consecutive quarterly status reports is required within one month after the close of the calendar quarter in which notification to purchasers occurs.Therefore, the first quarterly report will be due on, or before, 30 days after the close of the calendar quarter.